1. Registration trouble? Please use the "Contact Us" link at the bottom right corner of the page and your issue will be resolved.
    Dismiss Notice

Geo Tracker/Suzuki Sidekick Disc Brake Solution For Early CJ5's

Discussion in 'Early CJ5 and CJ6 Tech' started by tarry99, Mar 23, 2018.

  1. givemethewillys

    givemethewillys Been here since sparky ran it. 2022 Sponsor

    Why not just keep the transfer case parking brake?
     
  2. Jrobz23

    Jrobz23 Member

    Of the half dozen, or so, early CJ5's I've owned, not one worked. Again, midwest usage, so it wasn't an issue. On a early, fixing it is certainly an option. I've even seen some converted to a disc brake at one point. I'd personally use a line lock over a tcase brake, but that's just me.

    On the Roxor side, it doesn't have one to start with.
     
  3. Lockman

    Lockman OK.....Now I Get It . 2024 Sponsor 2023 Sponsor 2022 Sponsor

    Painted Mine.....Like jeepstar says ; it's up to you.
    Lotsa media on file here.
    All Painted & New Timken's.JPG
     
    tripilio, CJMark and Michael Toews like this.
  4. nickmil

    nickmil In mothballs.

    Mine works quite well. Many on here have them that work quite well. What usually causes problems is transfer case rear output leaks soaking the shoes and drum.
     
  5. cayenne

    cayenne Member

    I’m stumped.
    Originally I had 11” drums all around with the Herm dual drum/drum master cylinder. I put the side kick conversion in the front and plumbed in a 2 lb residual valve and although it didn’t pull side to side anymore, the braking wasn’t as good. I removed the residual valve from the master cylinder and still not very powerful braking.
    after reading on here, I figure maybe it was the drum/drum master cylinder so I put in a manual disc/drum master cylinder from a 70’s E100 van with manual brakes (it was massive so lots and lots of clerancing.) plumbed in 10lb valve for the rear drums and just drove it around on wet streets.
    Rears lock up but I can not get the fronts to lock up even on wet roads. Pedal is firm so I don’t think I have an air problem. I have a proportioning valve plumbed in the rear line and I keep having the turn it down.
    is this normal? I don’t know if I have metallic or organic pads in front.
    Thanks for any suggestions
     
    Lockman likes this.
  6. Warloch

    Warloch Did you say Flattie??? Staff Member

    Sounds like a MC to Disc piston ratio problem. With disc fronts you nee to have same or preferably larger MC piston than the Caliper. Remember, its a volume and pressure mix that makes the clamping force.

    That or you have some obstruction keeping the calipers from clamping all the way.
     
  7. jeepstar

    jeepstar Well-Known Member 2024 Sponsor 2023 Sponsor 2022 Sponsor

    2 years in, give or take, and I need to replace the flex lines in front, as they have been wearing on the steering knuckle. that isnt good! I'm going to get stainless steel flex lines up front.
     
    Jrobz23 and truckee4x4 like this.
  8. Lockman

    Lockman OK.....Now I Get It . 2024 Sponsor 2023 Sponsor 2022 Sponsor


    No , it's not normal. Get rid of that residual valve . It's not used when you have a Proportioning valve. Also.......Double check that your Front brake lines are at the Front of your MC.
     
  9. Rich M.

    Rich M. Shoe salesman 2024 Sponsor 2023 Sponsor 2022 Sponsor

    Its often necessary to pull the calipers off the brackets, place a block of wood in it and point the bleeders straight up.
    You'd be surprised how much air is in there no matter how many times you bleed them and get straight fluid.
     
    Fireball and Lockman like this.
  10. truckee4x4

    truckee4x4 Grant Kaye 2023 Sponsor 2022 Sponsor

    I'd be interested in p/n's if you are successful.